Volvo Penta Earlier D3
Technical Specification: Current D3 series diesel range. Five-cylinder, 2.4-litre diesel, 110 hp to 220 hp. Oil capacity is approximately 8 litres of VDS 4.5 oil.
The D3 Volvo Penta diesel range is defined by earlier and later variants. Therefore some parts including impellers change part numbers between earlier models and the latest variants. The Volvo Penta D3 is a 5-cylinder, fresh water-cooled engine, quiet and environmentally efficient. The new D3 meets IMO NOx (D3-200 & D3-220), EU RCD Stage II, US. EPA Tier 3 emissions.
We can supply all parts for the Volvo Penta D3 including the range of D3 series spare parts, oil filters and fuel filters, crankcase breathers, drive belts and impellers, genuine D3 series exhaust elbows, oils and grease. We are also main Volvo Penta dealers for servicing and technical support.
Volvo Penta D3 genuine service parts are made to exacting standards to withstand the harsh saltwater environment in which marine diesel engines operate. If you need helps with any technical issue regarding your Volvo Penta D3, please call us.
The heat exchanger on any D3 should be cleaned and the "O" rings changed, every 5 years to prevent overheating.
Older D3 diesel engines may run on Volvo green coolant and newer ones may be using yellow VCS coolant. Please do not mix or change the coolant type once one or other has been used. If you are running on Volvo Penta green coolant, continue to use green coolant. Mixing yellow and green coolant can cause gelling and blockages within the cooling system.
Volvo Penta CAV fuel filter twin pack for 877766 and 877767, Part Number 3581078-2
This is a twin pack for 3581078, replacement CAV water fuel separator filters, part number 3581078 installed between the fuel tank and engine. Fits filters 877766 and 877767 or any CAV filter housing.
£19.53
All prices in the UK include VAT
This is a twin pack for 3581078, replacement CAV water fuel separator filters, part number 3581078 installed between the fuel tank and engine. Fits filters 877766 and 877767 or any CAV filter housing.
Volvo Penta fuel filter insert, part number 861014
Volvo Penta 10-micron fuel filter insert for the Volvo Penta fuel and water separator. This insert may have 2010TM on the top to help identify it.
£18.24
All prices in the UK include VAT
Volvo Penta 10-micron fuel filter insert for the Volvo Penta fuel and water separator. This insert may have 2010TM on the top to help identify it.
Volvo Penta Racor type diesel water separator copper hose connector, Part Number 954337
Volvo Penta Racor type, fuel filter and water separator copper hose connector using 3/8" copper hose for all Volvo Penta diesel engines and any other make from 13hp upwards.
£17.93
All prices in the UK include VAT
Volvo Penta Racor type, fuel filter and water separator copper hose connector using 3/8" copper hose for all Volvo Penta diesel engines and any other make from 13hp upwards.
Volvo Penta VCS-2 orange concentrate Coolant 1 Litre, Part Number 24383482
The continued improvement of new Volvo Penta engines with higher performance, more compact sizes and lighter materials raises the requirements for cooling and corrosion protection. Volvo Penta Coolant VCS-2 is orange and must not be mixed with green coolant.
£17.50
All prices in the UK include VAT
The continued improvement of new Volvo Penta engines with higher performance, more compact sizes and lighter materials raises the requirements for cooling and corrosion protection. Volvo Penta Coolant VCS-2 is orange and must not be mixed with green coolant.
Volvo Penta D Yacht Series 85mm Tacho fitting kit, Part Number 874708
Volvo Penta 85mm black Tacho fitting kit with black bezel front ring.
£17.17
All prices in the UK include VAT
Volvo Penta 85mm black Tacho fitting kit with black bezel front ring.
Volvo Penta Green Coolant Concentrate, 1 Litre, Part Number 22567185
Never mix with VCS yellow coolant. Your Volvo Penta was supplied with either Green or VCS yellow coolant. They must never be mixed nor swapped over.
£16.42
All prices in the UK include VAT
Never mix with VCS yellow coolant. Your Volvo Penta was supplied with either Green or VCS yellow coolant. They must never be mixed nor swapped over.
Volvo Penta Replacement Ignition Panel Rubber Button Seal, Part Number 828586
Volvo Penta Replacement Ignition Panel Rubber Button Seal.
£15.12
All prices in the UK include VAT
Volvo Penta Replacement Ignition Panel Rubber Button Seal.
Volvo Penta Racor type diesel water separator hose connector, Part Number 3825000
Volvo Penta Racor type, fuel filter and water separator hose connector using 10mm hose for all Volvo Penta diesel engines and any other make from 13hp upwards.
£14.80
All prices in the UK include VAT
Volvo Penta Racor type, fuel filter and water separator hose connector using 10mm hose for all Volvo Penta diesel engines and any other make from 13hp upwards.
Volvo Penta VDS 4.5 SAE 15W-40 diesel engine oil, 1 litre, Part Number 23909459
Volvo Penta VDS-4.5 SAE 15W-40 diesel engine oil, 1 litre. The high quality of VDS-4.5 oils allows in certain cases an increase in drain intervals. VDS 4.5 can be mixed with VDS-3.
£13.82
All prices in the UK include VAT
Volvo Penta VDS-4.5 SAE 15W-40 diesel engine oil, 1 litre. The high quality of VDS-4.5 oils allows in certain cases an increase in drain intervals. VDS 4.5 can be mixed with VDS-3.
Racor 2010TM diesel fuel filter insert - Parker Racor
Racor 2010TM diesel fuel filter insert with replacement seal for the Racor 500 turbine series and Volvo Penta fuel and water separator, part number 877762. This insert is 78mm diameter by 70mm high and may have 2010TM on the top in blue writing to help identify it.
£12.99
All prices in the UK include VAT
Racor 2010TM diesel fuel filter insert with replacement seal for the Racor 500 turbine series and Volvo Penta fuel and water separator, part number 877762. This insert is 78mm diameter by 70mm high and may have 2010TM on the top in blue writing to help identify it.
Volvo Penta Propeller Shaft Grease 25 gram twin pack, Part Number 828250
Propeller Shaft Grease 25-gram, twin pack for all marine use.
£11.45
All prices in the UK include VAT
Propeller Shaft Grease 25-gram, twin pack for all marine use.
Volvo Penta Racor type diesel water separator copper union, Part Number 954323
Volvo Penta Racor type, fuel filter and water separator copper union used with part number 954337 (3/8" hose connector) for any installation using 3/8" copper hose. Suitable for all Volvo Penta diesel engines and any other make from 13hp upwards.
£11.02
All prices in the UK include VAT
Volvo Penta Racor type, fuel filter and water separator copper union used with part number 954337 (3/8" hose connector) for any installation using 3/8" copper hose. Suitable for all Volvo Penta diesel engines and any other make from 13hp upwards.